Clutch repair of cars Opel Ascona C

Contactless ignition system — troubleshooting
Symptom/Cause(s) The starter turns but the engine does not start/ The plug under the coil cover came out and the insulating material leaked out of the coil*...

Clutch — Specification
General information Type - Dry single-plate clutch with diaphragm spring and cable drive Adjustment - Using the nut located on the cable near the clutch...

Clutch — General Description
All models covered by this manual are equipped with a single plate, diaphragm spring clutch housed in a pressed steel housing bolted to the flywheel. The...

Clutch — adjustment
1. The clutch is self-adjusting under normal conditions, however, after replacing the cable or driven disc, the following preliminary adjustment must be made....

Clutch cable — removal and installation
1. One of the most common reasons for replacing the clutch cable is damage, but sometimes this has to be done because the clutch pedal becomes too "hard" or...

Clutch pedal — removal and installation
1. Remove the trim panel under the dashboard. 2. Disconnect the clutch cable from the pedal and clutch release lever ( see previous section ). In this case,...

Clutch — removal, inspection and installation (engine and gearbox remain on the car)
Removal 1. A specific feature of the models under consideration is that they can replace the pressure and driven clutch discs, release bearing, clutch release...

Clutch — removal, inspection and installation (engine or gearbox removed from vehicle)
1. Gaining access to the clutch after removing the engine or gearbox (or engine with gearbox) ( see chapter 1 ) unscrew the bolts securing the clutch housing...

Release bearing, clutch release lever, bushings and seal — removal and installation
1. A sign of wear of the release bearing is a squealing sound when you press the clutch pedal with the engine running. 2. In order to get to the release...

Clutch — troubleshooting
Symptom/ Cause(s) Jerks when engaging the clutch/ The engine or gearbox mounts have become loose The driven disk linings are badly worn or oily The splines of...

Clutch and manual transmission (late models)
Clutch and transmission - modifications 1. All 5-speed models produced from 1988 onwards do not have a threaded plug in the rear cover. This means that for all...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Share information: