Volumes
Motor oil
Including filter:
- 1.4 l - 3.0 l
- 1.6 l - 3.5 l
- 1.8 and 2.0 L SOHC models - 4.0 L
- 20 XEJ and C 20 XE - 4.5 l
- X 20 XEV — 4.0 l
The amount of oil required to raise the level on the dipstick from the "MIN" to "MAX" mark:
- 1.6 l - 0.8 l
- All other models - 1.0L
Cooling system (approximately)
- Models 1.4L - 5.6L
- 1.6L models (except C 16 NZ2) - manual transmission - 5.8 l
- 1.6L models (except C 16 NZ2) - automatic transmission - 5.6 l
- SOHC C 16 NZ2 models, 1.8 and 2.0 l - manual transmission - 7.2 l
- SOHC models C 16 NZ2, 1.8 and 2.0 l - automatic transmission - 7.1 l.
- DOHC Models - 7.2L
Transmission
Manual transmission:
- F10, F13 — 1.6 l
- F16, F18, F20 — 1.9 l
Automatic transmission - when replacing - 3.0-3.5 l
The difference between the MAX and MIN marks on the oil level dipstick is approximately:
- At +20°C — 0.25 l
- At +80°C — 0.40 l
Power Steering Fluid:
- Approximately 1.0 l
Fuel tank:
- All models - 63.0±2 L
Washer fluid:
- Without headlight washers - 2.6 l
- With headlight washers - 4.5 l
Engine
- Fuel filter - Champion G102
Cooling system
Antifreeze mixture:
- 29% antifreeze down to -15°C
- 50% antifreeze down to -30°C
Fuel system
Note: Spark advance adjustment is not possible on some models. For adjustment, see Section 4A or 4B.**
Idle speed:
- 14 TM - 925±25 rpm
- 16 SV:
- Models with manual transmission - 925±25 rpm
- Automatic transmission models - 825±25 rpm
- 18 SV — 925±25 rpm
- With 16 NZ and X 16 SZ - 850±80 rpm
- From 16 NZ2 - 880±80 rpm
- From 16 NZ
- Models with manual transmission - 880±80 rpm
- Models with automatic transmission - 830±80 rpm
- 20 NE, C 20 NE and 20 SEH - 800±80 rpm
- 20 XEJ and C 20 XE - 940±80 rpm
- K 20 XEV — 850 ±160 rpm
CO content:
- All carburetor models - 0.5-1.5%
- 20 NE and 20 SEH - 1.0 max.
- 20 XEJ — 0.7-1.2%
- Fuel Injected Models - 0.3% (at 2800-3200 rpm)
Air filter element:
- 1.4 and 1.6 l "round type" - Champion W103
- 1.6 and 1.8 l "square type" - Champion U512
- 1.8 l "round type" - Champion is not installed
- 2.0 l — Champion U554
Fuel filter:
- 1.6, 1.8 and 2.0 l - Champion L201
Source is on the website (opelbook.ru)
Ignition system
- Ignition Timing Angle - See Section 5**
Spark plugs:
- SOHC models - Champion RN7YCC or RN7YC
- DOHC models:
- Except C20 XE and X20 XEV — Champion RC9MCC*
- C20 XE and X20 XEV - Opel P/N 90444724 (FR8LDC)
Interelectrode gap:
- RN7YCC and RC9MCC* — 0 8 mm
- RN7YC* — 0.7 mm
- FR8LDC — 0.7-0.8 mm
*Information applies to Champion spark plugs.
Brakes
Minimum brake lining thickness (including support shield):
- All models - 7.0 mm
Minimum brake lining thickness:
- All models - 0.5mm above rivet head
Tires
Tire size:
- Wheels 51/2 J x 13 — 165 R13-82T
- Wheels 51/2 Jx14 - 175/70 R14-82T, 195/60 R14-85H, or 195/60 R14-85V
- Wheels 6J x 15 - 195/60 R15-87V or 205/55 R15-87V
Pressure - See. "Weekly checks"
Tightening torques, Nm:
- Automatic Transmission Drain Plug - 45
- Wheels - 110
- Spark plugs - 25
- Drain plug (pan) - 55
Visitor comments