Vehicle Maintenance Opel Astra G

General information about maintenance
This Chapter has been compiled to help the vehicle owner maintain his vehicle in a state of maximum operational readiness, obtaining effective output from it...

Schedule of current maintenance
The intervals for routine vehicle maintenance specified in this Section are designed for the independent performance of all necessary procedures by the vehicle...

Routine Maintenance Specifications
Recommended lubricants and fluids Listed below are the lubricants and fluids recommended by the vehicle manufacturer at the time of writing this manual. More...

General information about settings and adjustments
The term "settings" in this Manual does not mean a separate procedure for adjusting any of the parameters of the vehicle's systems, but a whole range of...

Checking fluid levels
Some special maintenance procedures that require additional fluid level checks are also described below. Look under your vehicle regularly for signs of...

Checking the condition of the tires and their inflation pressure, rotating the wheels
Examination A conscientious attitude to regular tire checks will allow the driver to avoid annoying delays associated with a tire failure while driving. In...

Changing engine oil and oil filter
When operating the vehicle under high stress conditions (see Schedule of current maintenance ) the engine oil/oil filter should be replaced every 5000 km. A...

Checking the condition and replacing the auxiliary drive belt
Examination Typical examples of V-belt wear Typical examples of wear of multi-groove drive belts Drive belts, or V-belts as they are sometimes called, are...

Removal sediment from a diesel engine fuel filter
Before performing any maintenance on the fuel filter, thoroughly wipe the area around the filter to prevent dirt from entering the fuel system. To collect any...

Checking the condition and replacing the hoses located in the engine compartment
Replacement of the hoses of refrigerator lines to / In should be left to the specialists of the car service workshop, who have the necessary equipment and have...

Checking the condition of the cooling system components
A wide range of engine failures are associated with a malfunction of the cooling system. On models equipped with AT, this system also provides ATF cooling,...

Checking, servicing and charging the battery
All models considered in this Manual are equipped with a sealed, maintenance-free battery as standard. Below is some information that may be useful to car...

Checking the condition and replacing the windshield wipers
The condition of the windshield wiper assemblies should be checked regularly in accordance with the vehicle's routine maintenance schedule (see Schedule of...

Inspection of suspension and steering components, checking the condition of the drive shaft protective covers
The condition of the suspension and steering components should be checked regularly, as their wear or damage can cause a reduction in the service life of the...

Checking the brake system
Remember that the dust generated by the brake mechanisms may contain asbestos, which is extremely harmful to human health. Never blow off dust with compressed...

Checking electrical equipment
1. Check the proper functioning of all on-board electrical consumers, including headlights, direction indicators, horn, windshield wiper motors and washer...

Monitoring the condition of the anti-corrosion coating of the car body and underbody
The condition of the anti-corrosion coating of the body is checked by specialists of the representative office of the new car manufacturer when extending the...

Lubrication of locks, hinges and stops
1. Walk around the car and lubricate the hinges and stops of the doors, hood and trunk lid with light engine oil. 2. Lubricate the hood lock and the protruding...

Resetting the service interval indicator
The Astra and Zafira models are equipped with a service interval indicator installed in the lower half of the speedometer. When 500 km/week remain until the...

Replacing the air cleaner filter element — diesel models produced before 09.2000
The air cleaner is installed in the front right corner of the engine compartment (see illustrations at the beginning of the Chapter). 1. Release the retainers...

Replacing the cabin filter
1. Remove the glove box and the lower section of the instrument panel trim (see Chapter Body ). Remove the air supply hose to the passenger footwell. 2. The...

Replacing the fuel filter — diesel models produced before 09.2000
Fuel filter design 1 - Central bolt 2 — Sealing element 3 - Lid 4 — Sealing ring 5 — Filter element 6 — Spring 7 — Body 1. Drain diesel fuel from the fuel...

Checking idle speed and exhaust gas composition
On heavily used vehicles (taxi, rental) this check should be performed annually, under normal operating conditions it will be sufficient to perform it once...

Replacing the air cleaner filter element — all petrol and diesel models produced since 10.2000
Cm. Replacing the air cleaner filter element - diesel models produced before 09.2000 .

Replacing the fuel filter — diesel models produced since 10.2000
Cm. Replacing the fuel filter - diesel models produced before 09.2000 .

Replacing spark plugs, checking the condition of high-voltage wiring
The electronic ignition system generates very high voltage! Be careful and take all necessary precautions when servicing any components of the system,...

Replacing the Fuel Filter — Petrol Models
Remember that gasoline is a highly flammable liquid! When working with fuel system components, observe all accepted fire safety measures. Do not smoke! Do not...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Share information: