Opel Astra F (petrol) car manual box

Technical specifications
Type - Five forward gears and one reverse gear, synchronizers on all forward gears Manufacturer's marking of the unit Models with 1.4 l carburetor engines and...

General information about manual transmission
All models are equipped with a five-speed gearbox; six different types are used depending on the model and power. There are some, although minor, differences...

Gearbox Oil — Draining and Filling
Drain On models equipped with twin cam engines, remove the lower engine splash shield as directed in chapter 11 . Place a container under the differential...

Gear shift mechanism — adjustment
While working in the engine compartment, loosen the bolt securing the gear shift lever rod to the bushing (Fig. 7.2). Remove the plug from the adjustment...

Gear shift mechanism — removal, repair and installation
Gear shift lever Make sure the lever is in neutral position. Pull the front edge of the shift lever boot away from the center console to access the base of the...

Speedometer drive — removal and installation
If necessary, disconnect the negative battery terminal and unplug the vehicle speed sensor connector. Loosen the clamp sleeve and disconnect the speedometer...

Manual transmission seals — replacement
Seals (drive shaft) side of differential Note: This operation requires a ball joint removal tool. In addition, the lower arm to strut ball joint retaining pins...

Reverse Light Switch — Removal, Installation and Testing
The reverse light circuit is activated by a plunger-type switch mounted on the gearbox housing. To test the switch, disconnect the wire and use a measuring...

Manual gearbox — removal and installation
Note: This is a fiddly job and in many cases it is easier to remove the transmission together with the engine as described in chapter 2 . If you are removing...

Manual gearbox — repair, general information
Complete repair of a manual gearbox is a complex task and requires special tools. It is recommended to either install a new or refurbished gearbox or to have...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Share information: