Ignition system (petrol models)
Type - Electronic with direct ignition (without distributor)
Ignition order - 1-3-4-2 (the first cylinder is located on the timing side)
Engine management system
OBD II trouble codes read from the memory of the control module using a diagnostic scanner
Remark: Failure indicator lamp (MIL) lights up when there is a problem with the system.
For more information on codes for your model, please visit www.obdil.com, www.obd-2.com and www.obd-2.de.
Information content of OBD II code bits
Example: P 0 3 8 0
From left to right:
1 rank
P power unit
in body
with chassis
2nd category (code source)
0 standard BAE
1 extended - factory-defined
3rd category (system)
0 system as a whole
1 air mixing (air/fuel induction)
2 fuel injection
3 ignition system or misfiring
4 optional release control (auxiliary emission control)
5 vehicle speed and idle control
6 input and output signals of the control unit
7 transmission
4.5 digits
Sequence number of component or circuit failure (00-99)
The main fault codes of the power unit
P0000 No trouble codes in system memory
P0100 Malfunction in the air mass measurement sensor circuit (MAF)
P0101 MAF malfunction
P0102 Excessively low signal level (short circuit «-») MAF sensor
P0103 Excessively high signal level (short circuit «+») MAF sensor
P0104 Intermittent error in the operation of the MAF sensor
P0105 Malfunction in the absolute pressure sensor circuit in the intake manifold (IDA)
P0106 Malfunction of the MAP
P0107 Excessively low signal level (short circuit «-») MAP sensor
P0108 Signal level too high (short circuit «+») MAP sensor
P0109 Intermittent error in the operation of the MAP sensor
P0110 Malfunction in the intake air temperature sensor circuit (IAT)
P0111 Malfunction of the IAT sensor
P0112 Excessively low signal level (short circuit «-») IAT sensor
P0113 Signal level too high (short circuit «+») IAT sensor
P0114 IAT sensor intermittent error
P0115 Malfunction in the coolant temperature sensor circuit (EATING)
P0116 Malfunction of the ECT sensor
P0117 Signal level too low (short circuit «-») ECT sensor
P0118 Excessively high signal level (short circuit «+») ECT sensor
P0119 Intermittent error in the operation of the ECT sensor
P0120 Malfunction in the throttle position sensor circuit (TPS)
P0121 TPS sensor malfunction
P0122 Excessively low signal level (short circuit «-») TPS sensor
P0123 Excessively high signal level (short circuit «+») TPS sensor
P0124 Intermittent error in the operation of the TPS sensor
P0130, 0150 Malfunction in the pre-catalytic lambda probe circuit (right row of cylinders on a V-shaped engine)
P0135 Excessively high voltage in the lambda probe heating circuit
P0190, 0191 The operation of the injection pump / injection pressure sensor is malfunctioning (on the fuel R line)
P0192 Excessively low voltage level (short circuit «-») injection pressure sensor
P0193 Excessively high voltage level (short circuit «+») injection pressure sensor
P0194 Intermittent error in the operation of the injection pressure sensor
P0195 Malfunction in the engine oil temperature sensor circuit
P0196 The engine oil temperature sensor malfunctioned
P0197 Signal level too low (short circuit «-») engine oil temperature sensor
P0198 Excessively high signal level (short circuit «+») engine oil temperature sensor
P0199 Intermittent error in the functioning of the engine oil temperature sensor
P0200 Malfunction in the fuel injection circuit
P0201 + 0204 Malfunction in the cylinder injector circuit 1-4, respectively
P0215 Violation of the functioning of the shut-off solenoid valve
P0217 Engine overheating
P0219 Inadmissible overspeed of the engine
P0335 Malfunction in the crankshaft position sensor circuit (TFR)
P0336 Violation of the functioning of the CKP sensor
P0337 Signal level too low (short circuit «-») SKR sensor
P0338 Excessively high signal level (short circuit «+») SKR sensor
P0339 Intermittent error in the functioning of the CKP sensor
P0340 Malfunction in the camshaft position sensor circuit (SMR)
P0341 Malfunction of the CMP sensor
P0342 Excessively low signal level (short circuit «-») CMP sensor
P0343 Excessively high signal level (short circuit «+») CMP sensor
P0344 Intermittent error in the operation of the CMP sensor
P0351 Ignition signal for cylinders 1 and 4
P0352 Ignition signal for cylinders 2 and 3
P0400 Deviation from the norm of the intensity of exhaust gas recirculation (EGR)
P0401 Excessive weakening of the EGR flow
P0402 Excessive amplification of the EGR flow
P0403 Malfunction in the EGR control solenoid valve circuit
P0404 Malfunction of the EGR control solenoid valve
P0410 Malfunction of the relay of the e / magnet of the additional air mixing system
P0412 Malfunction in the valve circuit of the additional air mixing system
P0440 Malfunction in the EGR valve position sensor circuit (EGR)
P0443 Malfunction in the EVAP carbon adsorber purge control valve circuit
P0460 Malfunction in the fuel level sensor circuit
P0461 Malfunction of the fuel level sensor
P0462 Excessively low signal level (short circuit «-») fuel level sensor
P0463 Excessively high signal level (short circuit «+») fuel level sensor
P0464 Intermittent error in the functioning of the fuel level sensor
P0500 Malfunction in the vehicle speed sensor circuit (VSS)
P0501 Malfunction of the VSS sensor
P0502 Excessively low signal level (short circuit «-») VSS sensor
P0503 Signal level too high (short circuit «+») VSS sensor/intermittent SS operation error
P0505 Malfunction in the IAC sensor circuit for idling speed stabilization
P0506 Unexpected underestimation of the engine speed when the idle speed stabilization system is activated
P0507 Unexpected increase in engine speed when the idle speed stabilization system is triggered
P0530 Malfunction in the refrigerant pressure sensor circuit of the K / V system
P0531 Violation of the functioning of the coolant pressure sensor of the K / V system
P0532 Excessively low signal level (short circuit «-») coolant pressure sensor of the K/V system
P0533 Signal level too high (short circuit «+») coolant pressure sensor of the K/V system
P0534 Discharging (loss of refrigerant) in the cooling circuit of the A/C system
P0560 Malfunction in the onboard power supply system
P0561 Violation of the stability of the on-board power supply voltage
P0562 Undervoltage on-board power supply
P0563 Overvoltage on-board power supply
P0606 ECM failure
P0650 Malfunction in the failure control lamp circuit (MIL)
P0654 Malfunction in the engine speed output signal circuit
P0655 Malfunction in the output signal circuit of the engine overheating warning lamp
P0656 Malfunction in the fuel level output signal circuit
P0703 Malfunction in the sensor-switch circuit of the foot brake pedal position (WRR)
P0704 Malfunction in the clutch sensor-switch circuit (SRR)
P0725 Malfunction in the crankshaft position sensor circuit (TFR)
P0726 Malfunction of the CKP sensor
P0727 No CKP sensor signal
P0728 Intermittent error in the operation of the CKP sensor
P1100 Malfunction of the air mass measurement sensor (MAF)
P1110 Open or short circuit in the EGR throttle control valve circuit
P1120 Malfunction of the absolute pressure sensor in the pipeline (IDA)
P1125 Malfunction of the turbocharger reset control valve
P1173 Activation of the engine overheating protection system, oil / coolant / fuel temperature
P1180 Malfunction of the fuel temperature sensor
P1220 Violation of the gas distribution control of the injection system
P1229 Supply voltage
P1230 Supply voltage
P1231 Malfunction of the engine control relay
P1326 Mixture Knock Control - Cylinder #1
P1327 Knock control mixture - cylinder number 2
P1329 Mixture knock control - cylinder number 4
P1335 ECM does not output engine speed data to injection pump
P1345 The injection pump control module does not detect camshaft speed
P1405 Malfunction of the EGR solenoid valve
P1501 Violation of the functioning of the immobilizer control module
P1502 No engine immobilization signal
P1503 Invalid engine immobilization signal
P1515 Violation of the functioning of the gas pedal position sensor (APP)
P1530 Open or short circuit in the circuit of the A/C compressor shutdown relay
P1560 System voltage too high
P1600 Malfunction of the ECM
P1601 ECM temperature too high
P1602 Knock control
P1604 Software error / malfunction of the ECM
P1605 Malfunction of the ECM
P1620 Engine control module (ECM) needs to be replaced
P1625 Violation of the operation of the engine control relay
P1630 Malfunction in the fuel quality regulator circuit
P1631 The injection pump control module needs to be replaced
P1635 Open or short circuit in the circuit of the preheat control module / malfunction of the module
P1640 Malfunction of the ECM
P1650 Error in the CAN data bus
P1651 Data transmission error of the injection pump control module on the CAN bus
P1690 Open or short circuit in the failure control lamp circuit (MIL)
P1694 Open or short circuit in the preheat control lamp circuit
Launch and charge systems
System type - 12-volt negative ground
Battery
Charge voltage, V - 12
Capacity, Ah - 36.44, 55, 60.66, or 70
Tightening force of threaded connections, Nm
Ignition module mounting bolts (petrol models) — 8
Bolts of fastening of the adjusting pallet of the storage battery to a body — 10
Battery Mounting Bracket Bolt - 15
Nuts of fastening of electroconducting of the generator
- Nut M6 - 5
- Nut M8 - 10
Z14XEP engine
- Alternator mounting bolts - 35
- Starter mounting bolts - 25
Z16XEP engine
- Alternator mounting bolts - 35
- Starter mounting bolts - 25
- Bolts of fastening of a support of an inlet air duct - 8
Z18XE engine
- Alternator mounting bolts - 35
- Multirib Belt Tensioner - 25
- The top bolt of fastening of the generator — 20
- The lower bolt of fastening of the generator — 35
- Upper starter mounting nut - 40
- Lower starter mounting bolt - 25
- Bolt of fastening of a protective bracket of a reception pipe of system of release of the fulfilled gases — 20
Z20LE engines (L/R/H)
- Bolts of fastening of a support of the generator — 35
- Fixing bolts of brackets of fastening of the generator — 20
- Alternator mounting bolts (Zafira) — 20
- Upper (long) starter mounting bolt - 40
- Lower starter mounting bolt - 45
- Bolts of a fastening bracket of a vacuum receiver — 25
Z22YH engine (Zafira)
- Alternator mounting bolts - 21
- Starter mounting bolts - 40
Z13DTH engine
- Alternator mounting bolts - 22
- Starter mounting bolts - 25
Z17DT engine (L/H)
- Alternator mounting bolts (M8) — 19
- Alternator mounting bolts (M10) — 46
- screw (M8) fixing the generator wiring cable - 10
- Vacuum hose of the amplifier of a brake drive - 18
- Oil supply hollow bolt - 22
- Lower starter mounting bolt - 38
- Top starter mounting bolt - 60
Z19DT engine (L/H)
- Alternator mounting bolts - 70
- Nuts of a fastening collar of the fuel filter - 25
Visitor comments