Diesel car engines Opel Kadett D
Diesel Engine — General Information
The OPEL KADETT D diesel engine is a 4-cylinder in-line engine with water cooling, it is installed at the front transversely to the direction of travel. The...
The OPEL KADETT D diesel engine is a 4-cylinder in-line engine with water cooling, it is installed at the front transversely to the direction of travel. The...
The most important technical characteristics of the engine
The most important technical characteristics of the engine Engine displacement, cm³ 1587 Power, mW, at rpm 40/4600 Torque. Nm at rpm 96/2400 Cylinder diameter,...
The most important technical characteristics of the engine Engine displacement, cm³ 1587 Power, mW, at rpm 40/4600 Torque. Nm at rpm 96/2400 Cylinder diameter,...
How a diesel engine works
Clean air is sucked into the cylinders of a diesel engine and is subjected to strong compression. As a result, it heats up to about 600°C. At this time,...
Clean air is sucked into the cylinders of a diesel engine and is subjected to strong compression. As a result, it heats up to about 600°C. At this time,...
Removal and installation the engine
The diesel engine, together with the gearbox and differential, is removed downwards. In specialized workshops, a hydraulic device is used for these chains to...
The diesel engine, together with the gearbox and differential, is removed downwards. In specialized workshops, a hydraulic device is used for these chains to...
Toothed Belt Drive — Design Description
Toothed belt drive 1 - camshaft drive gear; 2 - toothed belt; 3 - coolant pump gear; 4 - deflection roller; 5 - oil pump gear; 6 - Top dead center mark/high...
Toothed belt drive 1 - camshaft drive gear; 2 - toothed belt; 3 - coolant pump gear; 4 - deflection roller; 5 - oil pump gear; 6 - Top dead center mark/high...
Removal and installation the timing belt
Removal Disconnect the ground cable from the battery. Remove the air filter, see paragraph 4.44 . Remove the cover from the clutch housing, see item 9 . Remove...
Removal Disconnect the ground cable from the battery. Remove the air filter, see paragraph 4.44 . Remove the cover from the clutch housing, see item 9 . Remove...
Checking and adjusting the timing belt tension
The KM-510-A control device from OPEL is used to check the tension of the toothed belt. The KM-421 key is used to press the coolant pump to tension the toothed...
The KM-510-A control device from OPEL is used to check the tension of the toothed belt. The KM-421 key is used to press the coolant pump to tension the toothed...
Removal and installation the cylinder head
Removal Caution: The cylinder head can only be removed from a cold engine (room temperature, approximately 20°C). Disconnect the ground cable from the battery....
Removal Caution: The cylinder head can only be removed from a cold engine (room temperature, approximately 20°C). Disconnect the ground cable from the battery....
Removal and installation valves
Removal Remove the cylinder head and place it on two wooden blocks, see item 6.7 . Remove the rocker arms, stops and valve clearance compensators, see item 6.7...
Removal Remove the cylinder head and place it on two wooden blocks, see item 6.7 . Remove the rocker arms, stops and valve clearance compensators, see item 6.7...
Diesel engine malfunctions and how to fix them
Before searching for faults using the table, the following conditions must be met: No starting errors. Fuel in the tank, starter rotates normally (minimum 150...
Before searching for faults using the table, the following conditions must be met: No starting errors. Fuel in the tank, starter rotates normally (minimum 150...
This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian
See similar ones from other Opel car manuals:
▶ Power unit: Diesel engines Opel Ascona C (1981-1988)
▶ Power unit: Diesel engines 1.7 and 2.0 Opel Astra G (1998-2004)
▶ Power unit: Diesel engines Opel Corsa B (1993-2000)
▶ Power unit: Diesel engines 2.0 l Opel Omega B2 (1999-2003)
▶ Power unit: Diesel engines 2.8 l Opel Insignia A (2008-2017)
▶ Power unit: Diesel engines Opel Ascona C (1981-1988)
▶ Power unit: Diesel engines 1.7 and 2.0 Opel Astra G (1998-2004)
▶ Power unit: Diesel engines Opel Corsa B (1993-2000)
▶ Power unit: Diesel engines 2.0 l Opel Omega B2 (1999-2003)
▶ Power unit: Diesel engines 2.8 l Opel Insignia A (2008-2017)
Share information:
- General information
- Vehicle description
- Operation and maintenance
- OHV power unit
- Engine design
- Check and repair
- Engine work
- OHC power unit
- Engine design
- Engine repair
- Ignition system
- Cooling and lubrication
- Supply system
- Fuel injection «LE-Jetronic»
- Fuel injection «LE3-Jetronic»
- Motronic ML4.1 system
- Motronic M1.5 system
- Motronic M2.5 system
- Transmission
- Clutch
- Gearbox F10 and F13
- Gearbox F16 and F20
- Automatic gearbox
- Drive shafts
- Chassis
- Front suspension
- Rear suspension
- Steering
- Brake system
- Electrical equipment
- Equipment and devices
- Electrical circuits
- General information
- Car care
- Maintenance
- Power unit
- Gasoline engines
- Lubrication system
- Cooling system
- Power system (gasoline)
- Carburetor Solex 35 PDSI
- Carburetor Varajet II
- Carburetor 1B1
- Fuel injection (gasoline)
- Diesel engines
- Fuel system (diesel)
- Transmission
- Clutch
- Manual gearbox
- Chassis
- Front suspension
- Rear suspension
- Steering
- Brake system
- Wheels and tires
- Body
- Body elements
- Doors and windows
- Electrical equipment
- Equipment and devices
- Lighting system
- Power devices
- Ignition system
- Electrical circuits