Car steering Opel Zafira A (petrol)

Steering — Reference Data
Table 12.1. Basic data for monitoring, adjustment and maintenance Table 12.2. Tightening torques for threaded connections

Description of the steering design
The steering is trauma-safe, with an adjustable steering column, rack-and-pinion steering mechanism and hydraulic booster. The steering system consists of a...

Steering — checking technical condition
We perform the work with an assistant. Note: The work is shown on the Astra model. On the Zafira model it is done similarly. Sequence of execution 1. Make sure...

Steering wheel — removal and installation
Warning! Before performing any work involving the removal of the airbag modules or the airbag control unit, disconnect the negative battery cable and wait at...

Steering column trim — removal and installation
Removing the trim is necessary to access the parts and components located on the steering column. Removal 1. Prepare the car for work (see " Preparing the car...

Steering shaft — replacement
Replacing the steering shaft is necessary when the cardan joints of the shaft are heavily worn, which leads to increased play in the steering. Sequence of...

Tie Rod End — Replacement
To perform the work you will need a ball joint puller. Note: The work is shown using the example of replacing the left steering tip. The right steering tip is...

Steering Tie Rod Protective Boot — Replacement
It is necessary to replace the steering rod boot if it is damaged. It is also necessary to remove the boot when replacing the steering rod. Note: The operation...

Steering rod — replacement
Note: The operation is shown using the example of replacing the left steering rod. The right steering rod is replaced in the same way. Removal 1. Prepare the...

Power Steering System — Bleeding
After repairs involving depressurization of the power steering system, as well as if there is a suspicion of air getting into it, the power steering system...

Power Steering Pump — Replacement
To perform the work, you will need a container for the power steering fluid. Removal 1. Prepare the car for work (see " Preparing the car for maintenance and...

Steering gear — removal and installation
The steering gear must be removed for adjustment or replacement if the steering pressure test reveals a fault. Removal 1. Prepare the car for work (see "...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Share information: